×

Explosions rock flood-crippled chemical plant near Houston

  • Mike Cossey, of Bureau Veritas, uses an air monitor to check the quality of air at a police roadblock marking the 1.5-mile perimeter of the evacuation area around the Arkema Inc. chemical plant Thursday, Aug. 31, 2017, in Crosby, Texas. The Houston-area chemical plant that lost power after Harvey engulfed the area in extensive floods was rocked by multiple explosions early Thursday, the plant's operator said. The Arkema Inc. plant had been left without refrigeration for chemicals that become volatile as the temperature rises. (AP Photo/Gregory Bull) Gregory Bull

  • The Arkema Inc. chemical plant is shown Wednesday in Crosby, Texas, flooded from Tropical Storm Harvey on Wednesday. The plant, about 25 miles northeast of Houston, lost power to its backup generators amid Harvey’s dayslong deluge, leaving it without refrigeration for chemicals that become volatile as temperatures rise. AP

  • A man talks with officers at a roadblock less than three miles from the Arkema Inc. chemical plant Thursday, Aug. 31, 2017, in Crosby, Texas. The Houston-area chemical plant that lost power after Harvey engulfed the area in extensive floods was rocked by multiple explosions early Thursday, the plant's operator said. The Arkema Inc. plant had been left without refrigeration for chemicals that become volatile as the temperature rises. (AP Photo/Gregory Bull) Gregory Bull

  • Richard Rennard, president of acrylic monomers, America for Arkema Inc. speaks during a news conference Thursday, Aug. 31, 2017, in Crosby, Texas. The Houston-area chemical plant that lost power after Harvey engulfed the area in extensive floods was rocked by multiple explosions early Thursday, the plant's operator said. The Arkema Inc. plant had been left without refrigeration for chemicals that become volatile as the temperature rises. (AP Photo/Gregory Bull) Gregory Bull



Associated Press
Thursday, August 31, 2017

At least 2 tons of highly unstable chemicals used in such products as plastics and paint exploded and burned at a flood-crippled plant near Houston early Thursday, sending up a plume of acrid black smoke that stung the eyes and lungs.

The blaze at the Arkema Inc. chemical plant burned out around midday, but emergency crews continued to hold back because of the danger that eight other trailers containing the same compound could blow, too.

No serious injuries were reported. But the blast added a new hazard to Hurricane Harvey’s aftermath and raised questions about the adequacy of the company’s master plan to protect the public in the event of an emergency in the flood-prone Houston metropolitan area of 5.6 million people.

“This should be a wake-up call (for) all kinds of plants that are storing and converting reactive chemicals in areas which have high population densities,” said Nicholas Ashford, a Massachusetts Institute of Technology expert.

The Environmental Protection Agency and Texas environmental regulators called the health risks minimal in Crosby but urged residents downwind to stay indoors with windows closed to avoid inhaling the smoke.

Arkema had warned earlier in the week that an explosion of organic peroxides stored at the plant was imminent because Harvey’s floodwaters engulfed the backup generators and knocked out the refrigeration necessary to keep the compounds from degrading and catching fire.

All employees had been pulled from the plant before the blast, and up to 5,000 people living within 1½ miles had been warned to evacuate on Tuesday.

Two explosions in the middle of the night blew open a trailer containing the chemicals, lighting up the sky with 30- to 40-foot flames in the small farm and ranching community of Crosby, 25 miles from Houston, authorities said. Aerial footage showed a trailer carcass, its sides melted, burning in a flooded lot.

The Texas environmental agency called the smoke “especially acrid and irritating” and said it can impair breathing and inflame the eyes, nose and throat.

Fifteen sheriff’s deputies complained of respiratory irritation. They were examined at a hospital and released.

The U.S. Chemical Safety Board, an independent federal agency, launched an investigation into the accident.

The plant is along a corridor near Houston that contains one of the biggest concentrations of refineries, pipelines and chemical plants in the country.

Andrea Morrow, a spokeswoman for the Texas Commission on Environmental Quality, said the agency had not received any reports of trouble at other chemical plants in the hurricane-stricken zone.

Texas A&M chemical safety expert Sam Mannan said the risk management plan that Arkema was required by state and federal law to develop did not address how it would deal with power and refrigeration failures or flooding.

A 2016 analysis he did with university colleagues ranked the Crosby plant among the 70 or so facilities with the biggest potential to cause harm in greater Houston, based on such factors as the type and amount of chemicals and the population density.

Arkema, which is headquartered in France, did not immediately return calls on the plant’s contingency planning.

Rachel Moreno, a spokeswoman for the fire marshal of Harris County, which encompasses Houston, would not discuss details of the risk management plan, such as how high the plant’s backup generators were placed.

Arkema officials did not directly notify local emergency managers of the generator failure, Moreno said. It came, instead, by way of the plant’s workers, who told the Crosby Volunteer Fire Department about it when they were rescued during the hurricane, she said.

On Thursday, Rich Rennard, an executive at Arkema, said the chemical compounds were transferred to refrigerated containers after power was lost. But he said those containers failed too, causing the chemicals in one unit to burn. Rennard said more explosions were expected from the remaining containers.

State and federal regulators have cited Arkema for safety and environmental violations at the Crosby plant dating back more than a decade, records show.

Texas’s environmental commission penalized the company at least three times for a total of about $27,000, some of which was deferred pending corrective actions. Arkema denied the allegations.

During the last five years of compliance monitoring at the plant, state officials found five Clean Air Act-related deviations and two deviations from federal requirements on waste management, U.S. Environmental Protection Agency records show.

In June 2006, the company had failed to prevent unauthorized emissions during a two-hour warehouse fire. Records show a pallet of organic peroxide was poorly stored, resulting in the blaze, and more than a ton of volatile organic compounds were discharged.

The biggest penalty, about $20,000, came in December 2011 after the commission found Arkema had failed to keep thermal oxidizers, used to decompose hazardous gases, at high enough temperatures over the course of several months.